Honda GXV340 Troubleshooting
| Engine Model: Honda GXV340 |
| Engine Type: 4-cycle 1-cylinder OHV vertical shaft air-cooled gasoline |
| Total Displacement: 20.6 cu.in (337 cc) |
| Rated Engine Power: 11 Hp (8.2 kW) at 3600 rpm |
| Carburetor Type: Horizontal with butterfly valve |
____________________________________________________________________________________
| Engine hard to start or doesn't start |
Empty fuel tank - Fill gasoline up.
Incorrect fuel grade - Use correct gasoline grade.
Fuel system clogged - Repair or replace.
Spark plug wiring connection is defective - Check the spark plug wire connection, repair or replace.
Defective spark plug - Change spark plug as required.
Fuel filter is dirty - Change fuel filter.
Faulty safety switch - Change damaged switch.
Carburetor incorrectly set - Set carb correctly.
Low engine compression - Inspect cylinder block and change defective components.
Throttle cable is adjusted improperly or worn - Change cable or adjust properly.
Plugged cooling fins - Wash or clean as required.
Ignition system failure - Check ignition and replace faulty components.
Throttle cable is stuck or defective - Replace or service the cable.
Air filter element is plugged - Service or replace air filter.
Dirty or defective fuel pump - Service or change fuel pump.
| Engine starts but then stops |
Damaged spark plug - Change spark plug.
Faulty or dirty carburetor - Service or change carburetor.
Damaged ignition coil - Ignition coil must be replaced.
Weak or damaged valve springs - Valve springs need to be changed.
Valves sticking - Valves must be cleaned.
Engine oil level is low - Need to add engine oil.
Engine is under excessive load - Load reducing required.
Clogged cooling fins - Clean and wash as required.
Carburetor mixture is too lean - Set the carburetor properly.
Incorrect ignition timing - Ignition timing needs to be adjusted correctly.
Valve setting is incorrect - Valves needs to be adjusted properly.
| Abnormal engine knocking or noise |
Low octane fuel - Change gasoline.
Engine is overloaded - Load reducing required.
Low engine oil level - Fill up the oil to required level.
Incorrectly set low idle speed - Correct idle settings.
Fuel pump is damaged or dirty - Inspect fuel pump and change as required.
Main bearings or crankshaft failure - Worn parts replacement required.
Valve clearance is wrong - Adjust to proper valve clearance.
Damaged piston rings or cylinder bore - Replace defective components.
Carburetor is incorrectly adjusted or dirty - Adjust the carburetor properly or clean it.
Air filter is blocked - Replace or clean air filter.
Clogged or defective fuel pump - Service or change fuel pump.
Ignition failure - Inspect ignition system and change faulty parts.
Damaged cylinder-head gasket - Replace the head gasket.
Valves are stuck or burned - Replace or clean valves.
Damaged or worn push rod - Replace push rod.
Damaged cylinder block components - Defective parts need to be replaced.
Oil filter is blocked (if equipped) - Clean or replace oil filter.
| Engine using too much gasoline |
Throttle is not fully open - Change or adjust throttle cable.
Carburetor main jet adjustment is incorrect - Adjust the carburetor main jet correctly.
Loose or defective spark plug - Spark plug need to be tightened or replaced.
Worn, stuck, or burned valves - Clean or replace valves.
Worn piston, rings, or sleeve - Replace faulty components as required.
Valve clearance is not correct - Need to adjust valve clearance.
| Engine using too much oil |
Gaskets or seals can be faulty - Replace worn parts to avoid leaks.
Valve guides or stems are damaged - Valves replacement required.
Worn or stuck piston rings - Replace piston rings.
Cylinder liner or piston is worn - Inspect liner and piston, replace as necessary.
Blocked breather hose or pipe - Service or replace.
____________________________________________________________________________________
| Small Engines Technical Specifications |
| Car Engines Technical Specifications |
| Outboard Engines Technical Specifications |
| Industrial Engines Technical Specifications |
